Golf Cart Battery Cables Exposed – Does Size Really Matter or Ezgo Golf Cart ?
For gas powered carts, the cables need only be of sufficient size to operate the starter motor, which is only for a few seconds at a time. So that answer is no, the originally installed cables are plenty sufficient in size. For those of us who have the more plentiful, battery powered carts, Ezgo Golf Cart in Kempton park the answer is somewhat more complicated. The short answer for us is, yes and no, depending upon what we expect from the cart or if modifications to the motor or controller have been made.
If the cart is absolutely bone stock (all original with no upgrades) and is used primarily as originally intended around the local course, the standard 6 AWG (aka 6 gauge or #6) cables are perfectly fine. Wire (cable) size is measured by a standard called American Wire Gauge or AWG and relates to the diameter or cross sectional area of the copper conductor itself. The smaller the AWG number, the larger the diameter, and hence, larger current carrying capacity. For example, a 2 AWG cable is larger than a 4 AWG which is larger than a 6 AWG. Most cart manufacturers use 6 AWG cables. The finest cables we have found so far are made by MaxiLink.com, which are super flexible and made for extreme duty electric vehicle use.
Ok, now for you guys that want better performance, we’ll get a little more technical. The maximum current that will ever go through your cables is when the cart is at rest and you mash the gas pedal to the floor. At that point in time, the controller puts out the max power it is capable of, and the motor experiences what is called “locked rotor” current draw, which can be hundreds of amperes. When the motor is in a stalled state, it requires tremendous energy to get it spinning to the rated RPM. If the motor were to stay in the stalled state (if there was some mechanical restraint that would not allow it to turn) the high current would continue to be absorbed by the motor until it actually burned up the windings.
Typically though, the motor begins to spin immediately, and the current drops down to 20 or so amperes within a few milliseconds (on a stock cart). There are four things that limit that maximum current; the resistance of the internal windings of the motor, the current capacity of the battery pack, the controller capacity and the resistance of the battery cables. The Battery Pack and Motor windings are pretty much fixed values. Keep these in mind because we will come back to them.
Surge Protectors Will Save Your Golf Cart Battery Charger And Your Money!
Aftermarket “high torque” or “high speed” motors installed to increase the carts performance are commonplace these days. Unfortunately, that additional performance requires additional power. The motor is only there to convert electrical energy into kinetic energy (not very efficiently either). High power motors have a lower internal resistance than stock, which in turn draws more current. If you remember from science class, power (in watts) is voltage (E) multiplied by the current (I). Since the voltage cannot go any higher than the battery’s 48volts (or 36volts), the current increases in order to satisfy the power demand of the motor. Unfortunately, this is where the resistance of the battery cables come into play. As the current increases in a conductor, power is lost in the form of heat at a rate of I2R, where R is the cable resistance.
In an ideal cable and to transfer max power, the cable resistance (R) should be zero ohms. Unfortunately all cables have some resistance. The cable resistance causes the voltage to drop (E=IR) and results in lost power to the motor. The solution; increase the size of the battery cables (the larger the cable the less the resistance). Of course, the cable diameter can only be increased within reasonable mechanical size limitations, but that is what is required to reap the full benefits of a high power aftermarket motor. Our example used the locked rotor current to explain the worst case effects. They are less drastic at partial throttle, where the current draw is significantly less.
If you want to do the drag racing, burnouts, wheelies and such with your cart though, you will need the bigger cables to supply the required massive inrush of current to the motor. Although the resistance of the cables seems tiny (#6 = 0.00047ohms/ft vs. #2 = 0.00015 ohms/ft), the voltage drop is significant when large currents are present, which will reduce performance. So for the high power motor users out there, use large diameter cables and keep them as short as possible. Size will matter to you. Look for other articles by Randy Wade and check out www.digitaloverdrivesystems.com regularly for news, tips and performance products including the new Maxilink Extreme Duty EV cables.
Interesting Facts About Ezgo Golf Cart in Pretoria:
About Ezgo Golf Cart in Pretoria:
At one point in time, the use of a golf cart was something only the somewhat wealthy could enjoy on a golf course. Those who were not able to afford the use of a golf cart often found themselves hauling their clubs over their shoulder as they walked the golf course. Well, times have changed. Golf carts are now the standard at almost all golf courses throughout the country. Very seldom do golfers carry their clubs over their shoulder anymore. Unfortunately, some recreational golfers like to treat the course golf cart like a toy rather than a purposeful mode of transportation. Often times, you can witness wreckless behavior exchanged between recreational golfers and the use of their golf carts. However, this is one minor annoyance as a result of the golf cart gaining popularity. Typically, golf carts are available for rent from the course clubhouse. Most golfers take advantage of this service. An alternative, if you have the money, would be to buy your own golf cart. However, this is costly, but you will not need to pay rent for a golf cart whenever you go to the course. Golf carts are available for purchase either new or used. New golf carts can be purchased from anywhere from about $4000 to $11,000 dollars. Many factors attribute to the cost, such as model, seating capacity, and any additional options that may be available. There are two types of golf cart engines, gas engine or electric engine. An alternative to new golf carts would be to purchase a used golf cart. Used golf carts are alot cheaper than new ones, and typically you can find a sufficient golf cart for less than $3000. Buying a used golf cart can be alot like buying a used car. You will need to thoroughly inspect it inside and out. Make sure to ask the owner any questions you may have about the golf cart. Always make sure to take it for a test drive before committing to a purchase.
Ezgo Golf Cart in Pretoria
Golf carts have a wide range of uses. Sure, the most obvious is for the golf course. But where else might you use a golf cart. Surprisingly almost anywhere short distances of travel are needed. Below, I'll talk about such instances where the use of a golf cart would be ideal. On the golf course, golf carts are the primary means of transportation aside from walking. Golf carts are convenient and easy to use by everyone. The use of the golf cart makes traveling across the golf course quick and painless. Typically, most golf courses use electric powered golf carts as opposed to gas powered golf carts. Several factors influence this decision, but more than likely they choose electric due to its quiet use. There are many large corporations that look to golf carts in order to help move people across large sites where businesses are located. For example, so much time can be saved by using a golf cart to travel across the worksite as opposed to walking by foot. If the need to go back and forth the workplace frequently, the amount of time saved by using the golf cart could be worth alot of money to the company compared to someone always walking. Many security companies use golf carts to patrol the grounds of a company that they are securing. The golf cart makes it easy to cover alot of ground in a little time. The quietness of the electric golf cart also is a bonus in that it may be quiet enought to catch suspecting crooks off guard. Golf carts have also been known to have a use on the home front, especially if you own alot of land. Sure, if you own a lot of land, you may have a tractor, or other large piece of machinery. Would anyone of them be as efficient as an electric golf cart? Chances are they are not, especially with the current gas prices. As noted above, there are many uses for golf carts aside from the golf course. Whether you are at the golf course, workplace, or even the homefront, the golf cart could be of use to you.
Golf Carts Can Be Used Off The Course Too
The Harley Davidson golf cart is a great, old buggy and those who have one consider themselves lucky. This particular vehicle has not been in production for several decades now, and this often means those buying one will not have the owner's manual that goes with the vehicle. One of the most common mistakes made by new owners is improperly mixing the fuel and oil. Without the owner's manual handy, this mistake is easy to understand. This article goes into how to properly mix the oil and fuel in a vintage Harley Davidson golf cart.
Before we go into the proper method for mixing the oil and fuel in a vintage Harley Davidson golf cart, let's be clear about one thing. Improper mixing can lead to severe damage in the engine. Once this damage occurs it has to be repaired if you want to operate the vehicle. These repairs can be time consuming and expensive. While you can certainly find Harley Davidson golf cart repair parts online, it is not always easy finding them. When you do find them, the price may be high simply due to the scarcity of these old parts. The best way to avoid having to make these repairs is to protect the engine by using the right fuel and oil mix.
If your Harley Davidson golf car has a recently rebuild engine, you want to use 3 ounces of good quality 2-cycle oil for each gallon of gas in the first tank of gas. Once this first tank is used up, decrease the oil to 1.5 ounces per gallon of gas. Keep in mind that this first tank (the one using 3 ounces of oil) may foul the plug. Be prepared to change out the plug before going to the second tank of gas. It is a lot less expensive to buy a new plug than it is to rebuild the engine.
Once you apply this mix to your Harley Davidson golf cart, you will be able to enjoy your vehicle without fear of burning the motor up. Take care of your vintage vehicle and don't forget to pass it on to someone who will care for it as you do.
- Ezgo Golf Cart Accessories Kempton park
- Ezgo Golf Cart Parts South Africa
- Ezgo Gas Golf Cart Randburg
- Ezgo Electric Golf Cart Alberton
- Ezgo Golf Cart Prices Alberton
- Ezgo Gas Golf Cart For Sale Centurion
- Ezgo Carts For Sale Johannesburg south
- Ezgo Electric Golf Carts For Sale Centurion
- Ezgo Golf Carts For Sale Near Me Midrand
- Custom Golf Carts Sandton
- Custom Golf Carts For Sale Fourways
- Custom Golf Cart Bodies Johannesburg south
- Used Custom Golf Carts For Sale Gauteng
- Used Custom Golf Carts Kempton park
- Custom Golf Clubs Kempton park
- Custom Golf Cart Accessories Benoni
- Custom Golf Centurion
- Custom Golf Cart Wheels Fourways